Formation of Anti-Reflection Coatings Based on Nanostructured Aluminum and Barium Titanate Xerogel Layer
https://doi.org/10.35596/1729-7648-2024-22-3-14-20
Abstract
The research has been carried out on the formation of anti-reflection coatings based on porous aluminum obtained by electrochemical anodic etching and a layer of barium titanate xerogel deposited on its surface. The thickness of the porous aluminum ranged from 15 to 100 microns. Analysis of the reflection spectra of the resulting structures showed effective anti-reflection properties of the formed coatings with a specular reflection coefficient of 0.25–2.50 % in the range of 200–1100 nm. The use of formed coatings with a low reflectance coefficient is possible in aircraft manufacturing, electronics and energy.
Keywords
electrochemical anodizing,
porous aluminum,
sodium chloride,
barium titanate xerogel,
anti-reflective properties
Supporting agencies: The work was carried out with the financial support of the project of the Belarusian Republican Foundation for Fundamental Research No Х23М-044.
About the Authors
S. K. Lazarouk
Belarusian State University of Informatics and Radioelectronics
Belarus
Belarus
Lazarouk Serguei Konstantinovich, Dr. of Sci. (Phys. and Math.), Professor, Professor at the Department of Micro- and Nanoelectronics, Head of the Scientific Research Laboratory “Integrated Micro- and Nanosystems” (Lab. 4.6) of R&D Department
220013, Minsk, P. Brovki St., 6
Tel.: +375 17 293-88-69
T. F. Raichenok
State Scientific Institution B. I. Stepanov Institute of Physics of the National Academy of Sciences of Belarus
Belarus
Belarus
Cand. of Sci., Leading Researcher at the Center “Photonics of Atomic and Molecular Structures”
Minsk
L. P. Tomashevich
Belarusian State University of Informatics and Radioelectronics
Belarus
Belarus
Electronics Engineer at the Lab. 4.6 of R&D Department
220013, Minsk, P. Brovki St., 6
E. I. Lashkovskaya
Belarusian State University of Informatics and Radioelectronics
Belarus
Belarus
Engineer at the Scientific Research Laboratory “Nanophotonics” (Lab. 4.5) of R&D Department
220013, Minsk, P. Brovki St., 6
A. A. Povzhik
OJSC “Minsk Research Institute of Radiomaterials”
Belarus
Belarus
Head of Sector SP-110
Minsk
N. V. Gaponenko
Belarusian State University of Informatics and Radioelectronics
Belarus
Belarus
Dr. of Sci. (Phys. and Math.), Professor, Professor at the Department of Micro- and Nanoelectronics, Head of the Lab. 4.5 of R&D Department
220013, Minsk, P. Brovki St., 6
References
1. Is akov K., Kauppinen C., Franssila S. (2020) Superhydrophobic Antireflection Coating on Glass Using Grass-Like Alumina and Fluoropolymer. ACS Applied Material Interfaces . 12 (44), 49957–49962.
2. Soon H. L., Nguen H. L., Jung A. L. (2021) Nanopatterned Polymer Molds Using Anodized Aluminum Templates for Anti-Reflective Coating. Polymer MDPI. 13 (19), 3333–3342.
3. Raid A. I., Shihab A. Z., Rafal M. K. (2017) Preparation and Characterization of Aluminum Oxide Nanoparticles by Laser Ablation in Liquid as Passivating and Anti-Reflection Coating for Silicon Photodiodes. Appl. Nanoscience. (7), 477–487.
4. Goldsmith J., Vasilyev V., Vella J. (2014) Black Aluminum: A Novel Anti-Reflective Absorbing Coating. United States Air Force Research Laboratory. Wright-Patterson AFB. 69–70.
5. Kumar R. H., Ganesh A., Sreekumaran N. (2011) Anti-Reflective Coatings: A Critical, In-Depth Review. Energy and Environmental Science. 4, 3779–3804.
6. Gaponenko N. V., Kholov P. A., Raichenok T. F., Prislopski S. Ya. (2019) Enhanced Luminescence of Europium in Sol-Gel Derived BaTiO3/SiO2 Multilayer Cavity Structure. Optical Materials. 96.
7. Lazarouk S. K. (2013) High Field Porous Anodization of Aluminium Films with a Photolithographic Mask. Physics, Chemistry and Application of Nanostructures . 355–358.
8. Chu S., Wada K., Inoue S., Isogai M., Yasumori A. (2005) Fabrication of Ideally Ordered Nanoporous Alumina Films and Integrated Alumina Nanotubule Arrays by High-Field Anodization. Advanced Materials. 17, 2115– 2119.
9. Lazarouk S. K., Sasinovich D. A., Dudich V. V., Lazarouk A. S., Borisenko V. E. (2022) Formation of Alumina Nanotubes and Jet Effect during High-Voltage Local Anodization of Aluminum. Advanced Engineering Materials . 24 (1).
10. Lazarouk S., Bondarenko V., Pershukevich P., La Monica S., Maiello G. (1994) Visible Electroluminescence from Al-Porous Silicon Reverse Bias Diodes Formed on the Base of Degenerate n-Type Silicon. MRS Online Proceedings Library Archive. 358, 659–664.
11. Lazarouk S., Bondarenko V., La Monica S., Maello G., Masini G., Pershukevich P., et al. (1996) Electroluminescence from Aluminum-Porous Silicon Reverse Bias Schottky Diodes Formed on the Base of Highly Doped n-Type Polysilicon. Thin Solid Films . 276, 296–298.
12. Lazarouk S. K., Leshok A. A., Labunov V. A., Borisenko V. E. (2005) Efficiency of Avalanche Light-Emitting Diodes Based on Porous Silicon. Semiconductors. 39 (1), 136–138.
13. Jaguiro P., Katsuba P., Lazarouk S., Moore S., Smirnov A. (2009) Si-Based Optoelectronic Couple. Physica E: Low-Dimensional Systems and Nanostructures . 41, 1094–1096.
14. Lazarouk S., Katsouba S., Leshok A., Demianovich A., Stanovski V., Voitech S., et al. (2000) Porous Alumina as Lowe Insulator for Multilevel Metallization. Microelectronic Engineering. 50 (1–4), 321–327.
15. Lazarouk S. K., Leshok A. A., Kozlova T. A., Dolbik A. V., Le Dinh Vi, Ilkov V. K., et al. (2019) 3D Silicon Photonic Structures Based on Avalanche LED with Interconnections T hrough Optical Interposer. International Journal of Nanoscience . 18 (3, 4).
16. Lazarouk S. K., Sasinovich D. A., Katsuba P. S., Labunov V. A., Leshok A. A., Borisenko V. E. (2007) Electroluminescence of Nanostructured Silicon in Anodic Alumina Matrix. Semiconductors. 41 (9), 1126–1129.
17. Lazarouk S., Xie Z., Chigrinov V., Kwok H. S. (2007) Anodic Nanoporous Titania for Electro-Optical Devices. Japanese Journal of Applied Physics . 46.
18. Gaponenko N. V., Molchan I. S., Sergeev O. V., Thompson G. E., Pakes A., Skeldon P., et al. (2002) Enhancement of Green Terbium-Related Photoluminescence from Highly Doped Microporous Alumina Xerogels in Mesoporous Anodic Alumina. J. Electrochem. Soc. 149.
Review
For citations:
Lazarouk S.K., Raichenok T.F., Tomashevich L.P., Lashkovskaya E.I., Povzhik A.A., Gaponenko N.V. Formation of Anti-Reflection Coatings Based on Nanostructured Aluminum and Barium Titanate Xerogel Layer. Doklady BGUIR. 2024;22(3):14-20. (In Russ.) https://doi.org/10.35596/1729-7648-2024-22-3-14-20
Views: 453
Email this article 